umu.sePublikasjoner
Endre søk
RefereraExporteraLink to record
Permanent link

Direct link
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annet format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annet språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf
Distribution of temperature, H2O and atomic potassium during entrained flow biomass combustion: coupling in situ TDLAS with modeling approaches and ash chemistry
Umeå universitet, Teknisk-naturvetenskapliga fakulteten, Institutionen för tillämpad fysik och elektronik.
Umeå universitet, Teknisk-naturvetenskapliga fakulteten, Institutionen för tillämpad fysik och elektronik.
Umeå universitet, Teknisk-naturvetenskapliga fakulteten, Institutionen för tillämpad fysik och elektronik. Energy Engineering, Department of Engineering Sciences & Mathematics, Luleå University of Technology, SE-971 87 Luleå, Sweden.ORCID-id: 0000-0002-5777-9241
Umeå universitet, Teknisk-naturvetenskapliga fakulteten, Institutionen för tillämpad fysik och elektronik.
Vise andre og tillknytning
2018 (engelsk)Inngår i: Combustion and Flame, ISSN 0010-2180, E-ISSN 1556-2921, Vol. 188, s. 488-497Artikkel i tidsskrift (Fagfellevurdert) Published
Abstract [en]

Tunable diode laser absorption spectroscopy (TDLAS) is employed for simultaneous detection of gas temperature, water vapor (H2O) and gas-phase atomic potassium, K(g), in an atmospheric, research-scale entrained flow reactor (EFR). In situ measurements are conducted at four different locations in the EFR core to study the progress of thermochemical conversion of softwood and Miscanthus powders with focus on the primary potassium reactions. In an initial validation step during propane flame operation, the measured axial EFR profiles of H2O density-weighted, path-averaged temperature, path-averaged H2O concentration and H2O column density are found in good agreement with 2D CFD simulations and standard flue gas analysis. During biomass conversion, temperature and H2O are significantly higher than for the propane flame, up to 1500 K and 9%, respectively, and K(g) concentrations between 0.2 and 270 ppbv are observed. Despite the large difference in initial potassium content between the fuels, the K(g) concentrations obtained at each EFR location are comparable, which highlights the importance of considering all major ash-forming elements in the fuel matrix. For both fuels, temperature and K(g) decrease with residence time, and in the lower part of the EFR, K(g) is in excellent agreement with thermodynamic equilibrium calculations evaluated at the TDLAS-measured temperatures and H2O concentrations. However, in the upper part of the EFR, where the measured H2O suggested a global equivalence ratio smaller than unity, K(g) is far below the predicted equilibrium values. This indicates that, in contrast to the organic compounds, potassium species rapidly undergo primary ash transformation reactions even if the fuel particles reside in an oxygen-deficient environment.

sted, utgiver, år, opplag, sider
New York: Elsevier, 2018. Vol. 188, s. 488-497
Emneord [en]
Tunable diode laser absorption spectroscopy (TDLAS), Atomic potassium, Entrained flow reactor, Biomass combustion, Thermodynamic equilibrium calculations, Computational fluid dynamics (CFD)
HSV kategori
Identifikatorer
URN: urn:nbn:se:umu:diva-141456DOI: 10.1016/j.combustflame.2017.10.013ISI: 000424859100040Scopus ID: 2-s2.0-85032255301OAI: oai:DiVA.org:umu-141456DiVA, id: diva2:1154855
Prosjekter
Bio4EnergyTilgjengelig fra: 2017-11-06 Laget: 2017-11-06 Sist oppdatert: 2020-01-13bibliografisk kontrollert
Inngår i avhandling
1. Entrained flow studies on biomass fuel powder conversion and ash formation
Åpne denne publikasjonen i ny fane eller vindu >>Entrained flow studies on biomass fuel powder conversion and ash formation
2018 (engelsk)Doktoravhandling, med artikler (Annet vitenskapelig)
Alternativ tittel[sv]
Partikelomvandling och askbildning i pulverflammor
Abstract [en]

Reducing the global dependence on fossil fuels is of paramount importance in tackling the environmental challenges we face, not only tomorrow, but already today. Biomass offers a renewable supply of CO2-neutral raw material that can be converted into many different forms of fuels and valuable chemicals, making it a prime candidate for the technologies of tomorrow. However, the heterogeneous nature and distinctly different elemental composition of biomass compared to traditional fossil sources present new challenges to be solved. When it comes to thermochemical technologies, key issues concern fuel conversion efficiency, ash formation, ash/fuel interactions and ash/reactor material interactions.

The objective of the present thesis was to provide new knowledge and insights into thermochemical fuel conversion, in particular its application in entrained flow technologies. A laboratory-scale reactor was constructed, evaluated and was used to study several aspects of high-temperature entrained flow biomass fuel conversion. Pulverized fuel particles from different biomass sources were used, and their physical and chemical interactions with the surrounding atmosphere, the concurrent ash element release, ash formation, and phase interactions were also studied in detail. In addition to the entrained flow reactor designed and constructed for this purpose, the main method for data collection was in situ optical studies of converting particles, either while entrained in the flow or when impacting upon surfaces. Elemental composition analysis of collected samples and gas analysis were also performed, allowing for a deeper understanding of ash element fractionation and interactions and thus explaining the observed properties of the resulting deposits or slag.

The degree of conversion of fuels with very low ash content, such as stem wood, was well described and modeled by a novel method using optical data, offering a non-intrusive and non-destructive alternative to traditional techniques. Coupling computational fluid dynamics with optical data allowed for improved experimental data interpretation and provided improved accuracy for fuel particle residence time estimations, which is an important parameter when studying fast chemical reactions such as those taking place in reactors for entrained flow conditions. The results from studies on ash formation gave new insights into the feasibility of using dry-mixed K-rich additives for improving slag properties during gasification of Ca-rich and Si-rich fuels. Interpretations of the experimental results were supported by thermodynamic equilibrium calculations, and the conclusions highlight both possibilities and challenges in gasification with high fuel flexibility while at the same time producing a flowing slag. Applications and future implications are discussed, and new topics of interest are presented.

sted, utgiver, år, opplag, sider
Umeå: Umeå University, 2018. s. 63
Emneord
Thermochemical biomass conversion, particle image velocimetry, gasification, entrained flow reactor, ash transformation, equilibrium calculations, slag formation
HSV kategori
Identifikatorer
urn:nbn:se:umu:diva-152332 (URN)978-91-7601-937-5 (ISBN)
Disputas
2018-10-26, N430, Naturvetarhuset, Umeå, 10:00 (engelsk)
Opponent
Veileder
Forskningsfinansiär
Bio4EnergySwedish Research CouncilSwedish Energy Agency
Tilgjengelig fra: 2018-10-05 Laget: 2018-10-02 Sist oppdatert: 2018-10-18bibliografisk kontrollert

Open Access i DiVA

fulltext(820 kB)34 nedlastinger
Filinformasjon
Fil FULLTEXT01.pdfFilstørrelse 820 kBChecksum SHA-512
2214dddf29f5b3417e6bae947d173fe560e800b5ba17c1bbaef8296e59c648d062238a7ecad16f31d7c6c2524bc0664a497145b093bd245193efd7cc0a35e7b2
Type fulltextMimetype application/pdf

Andre lenker

Forlagets fulltekstScopus

Personposter BETA

Qu, ZhechaoHolmgren, PerSkoglund, NilsWagner, David R.Broström, MarkusSchmidt, Florian M.

Søk i DiVA

Av forfatter/redaktør
Qu, ZhechaoHolmgren, PerSkoglund, NilsWagner, David R.Broström, MarkusSchmidt, Florian M.
Av organisasjonen
I samme tidsskrift
Combustion and Flame

Søk utenfor DiVA

GoogleGoogle Scholar
Totalt: 34 nedlastinger
Antall nedlastinger er summen av alle nedlastinger av alle fulltekster. Det kan for eksempel være tidligere versjoner som er ikke lenger tilgjengelige

doi
urn-nbn

Altmetric

doi
urn-nbn
Totalt: 672 treff
RefereraExporteraLink to record
Permanent link

Direct link
Referera
Referensformat
  • apa
  • ieee
  • modern-language-association-8th-edition
  • vancouver
  • Annet format
Fler format
Språk
  • de-DE
  • en-GB
  • en-US
  • fi-FI
  • nn-NO
  • nn-NB
  • sv-SE
  • Annet språk
Fler språk
Utmatningsformat
  • html
  • text
  • asciidoc
  • rtf